Catalog: GM Goodwrench Engines Catalog
Company/Brand: GM Goodwrench
check engine light in GM Goodwrench Engines Catalog by GM Goodwrench
PROCEDURES cont. 19. Remove the engine from the engine stand. 20. Install the ... and clutch components. 21. Install the engine in the vehicle. After Installation ... battery is fully charged. Make sure the engine has been pre-lubed, the oil is at its ... proper level, and the engine is pressurized completely. Check the ... . Change as necessary. Pressure check the cooling system, not exceeding 20 ... psi (138 kPa). Check hoses, cylinder head and freeze plugs. ... Check the radiator core, transmission oil ... and is the correct application. Check the routing of the various other ... components, such as: Belts check the tension and adjust them accordingly ... Electrical harnesses check the ignition wiring and firing order, ... and the carburetor Intake system check the ducts, filters and vacuum hoses for ...
GENERAL ENGINE DIAGNOSTICS Section IV Page 26 August ... 2004 Engine Mechanical Diagnosis Diagnosing ... various engine mechanical concerns involves starting ... to that symptom. Also, using certain checks or tests to eliminate some causes and ... root cause. Concern Possible Cause Check or Test Engine will not turn over ... , solenoid) Hydrostatic lock Seized engine Turn engine over by hand to verify that ... bar to verify mechanical failure. Engine cranks, will not start Restricted ... cranking vacuum; locate restriction. Check for proper fuel pressure, injector ... timing. Perform compression test, check oil viscosity. Rough Idle Fuel, ... pushrod/broken valve spring Faulty engine mount Check/test engine vacuum, ... cause and residual damage. Load engine with brake applied, shift D-R-D as ...
GENERAL ENGINE DIAGNOSTICS Section IV Page 28 August ... 2004 Engine Noise Diagnosis Engine noises, like various symptoms of engine ... , can provide direction for specific checks and further testing. Noise Symptom ... Description Check or Test Double knock Light crankshaft ... the first few minutes after start-up. Check for a loose piston pin. Rattling Light ... for first few minutes of start-up. Light, regular, camshaft-speed ticking noise ... , heard best when the engine is increased to 2000 rpm, then ... released to idle Check for several loose piston pins. Check ... balance shaft bearing. Thumping Light, regular thumping noise heard best near ... accessory drive belt pulleys. Check drive belt pulley tensioner. Adjust to ... specified deflection. Check pulley alignment. Dull Knock Heavy, ...
GENERAL ENGINE DIAGNOSTICS Section IV Page 29 August ... 2004 Engine Noise Diagnosis cont. Noise Symptom ... Description Check or Test Tick GM C/K vehicles On cold ... start at low temperatures during engine deceleration after idle flare. Not ... 99-06-04-014 for details. Knock, engine cold. Continues for 2 to 3 minutes. ... belts; perform visual inspection. Check with bore gauge and T-gauge micrometer ... visual inspection. Heavy knock, engine hot, torque applied. Broken harmonic ... Visual inspection. Visual inspection. Light knock, engine hot, under light load ... . Excessive rod bearing clearance. Check engine codes and ignition timing ... settings; reset to specifications; check EGR for blockage. Owner input; use ... knock. Hydraulic lifter bleed down. Check filter with anti-drainback valve. ...
GOODWRENCH SERVICE REPLACEMENT ENGINES Section V Page 35 August 2004 ... 2.3A) 1990 Oldsmobile W (LG0)(2.3A) Engine-Specific Content: Camshaft Housing, Front Cover ... , Oil Check Valve, Oil Pan, Spark Plugs, and Water ... Pump INSTALLATION INSTRUCTIONS This engine has been remanufactured subsequent to ... service information (i.e., 1989 engines by incorporate design features normally ... If future service is necessary for this engine, consult GM Parts catalogs, GM Parts and ... revisions. Before installing this engine, refer to the appropriate vehicle ... repair procedures. After removing old engine, use new seals and gaskets and transfer ... tube and cap/indicator. Attach Quad IV engine decal (enclosed in instruction envelope ... ). Install replacement engine and add 4 quarts of Starburst certified ...
GOODWRENCH SERVICE REPLACEMENT ENGINES Section V Page 36 August 2004 ... Pontiac, Chevrolet N (LG0)(2.3A) Engine-Specific Content: Camshaft Housing, Front Cover ... , Oil Check Valve, P/S Pump Pulley, Spark Plugs, ... Pump INSTALLATION INSTRUCTIONS This engine has been remanufactured subsequent to ... service information (i.e., 1989 engines by incorporate design features normally ... If future service is necessary for this engine, consult GM Parts catalogs, GM Parts and ... revisions. Before installing this engine, refer to the appropriate vehicle ... repair procedures. After removing old engine, use new seals and gaskets and transfer ... tube and cap/indicator. Attach Quad IV engine decal (enclosed in instruction envelope ... ). Install replacement engine and add 4 quarts of Starburst certified ...
GOODWRENCH SERVICE REPLACEMENT ENGINES Section V Page 37 August 2004 ... , Oldsmobile, N (LD2)(2.3D) Buick Engine-Specific Content: Camshaft Housing, Front Cover ... , Oil Check Valve, Oil Pan, P/S Pump Pulley, Spark ... Pump INSTALLATION INSTRUCTIONS This engine has been remanufactured subsequent to ... service information (i.e., 1989 engines by incorporate design features normally ... If future service is necessary for this engine, consult GM Parts catalogs, GM Parts and ... revisions. Before installing this engine, refer to the appropriate vehicle ... repair procedures. After removing old engine, use new seals and gaskets and transfer ... tube and cap/indicator. Attach Quad IV engine decal (enclosed in instruction envelope ... ). Install replacement engine and add 4 quarts of Starburst certified ...
GOODWRENCH SERVICE REPLACEMENT ENGINES Section V Page 38 August 2004 ... Pontiac, Oldsmobile N (LD2)(2.3D) Engine-Specific Content: Camshaft Housing, Front Cover ... , Oil Check Valve, Oil Pan, P/S Pump Pulley, Spark ... Pump INSTALLATION INSTRUCTIONS This engine has been remanufactured subsequent to ... service information (i.e., 1989 engines by incorporate design features normally ... If future service is necessary for this engine, consult GM Parts catalogs, GM Parts and ... revisions. Before installing this engine, refer to the appropriate vehicle ... repair procedures. After removing old engine, use new seals and gaskets and transfer ... tube and cap/indicator. Attach Quad IV engine decal (enclosed in instruction envelope ... ). Install replacement engine and add 4 quarts of Starburst certified ...
GOODWRENCH SERVICE REPLACEMENT ENGINES Section V Page 42 August 2004 ... Buick 1990 Chevrolet W (LR8)(2.5R) Engine-Specific Content: Crankshaft Balancer, Front ... INSTRUCTIONS The Goodwrench 2.5 engine has been remanufactured subsequent to ... service information (i.e., 1982 engines may incorporate design features ... If future service is required for this engine, consult GM Parts catalogs, GM Parts and ... revisions. Before installing this engine, refer to the appropriate vehicle ... climate conditions. Prime system and check oil level on dipstick. Add oil as ... necessary components to the replacement engine. Thoroughly clean all old parts to ... manifold bolt MUST go through the engine lift bracket or an equivalent thickness ... lifter noise and possible damage to the engine. Rocker cover installation: A) use RTV ...
GOODWRENCH SERVICE REPLACEMENT ENGINES Section V Page 43 August 2004 ... Buick 1986 Chevrolet P (LR8)(2.5R) Engine-Specific Content: Crankshaft Balancer, Front ... INSTRUCTIONS The Goodwrench 2.5 engine has been remanufactured subsequent to ... service information (i.e., 1982 engines may incorporate design features ... If future service is required for this engine, consult GM Parts catalogs, GM Parts and ... revisions. Before installing this engine, refer to the appropriate vehicle ... climate conditions. Prime system and check oil level on dipstick. Add oil as ... necessary components to the replacement engine. Thoroughly clean all old parts to ... manifold bolt MUST go through the engine lift bracket or an equivalent thickness ... lifter noise and possible damage to the engine. Rocker cover installation: A) use RTV ...
GOODWRENCH SERVICE REPLACEMENT ENGINES Section V Page 44 August 2004 ... 1985 Chevrolet, Buick X (LR8)(2.5R) Engine-Specific Content: Crankshaft Balancer, Front ... INSTRUCTIONS The Goodwrench 2.5 engine has been remanufactured subsequent to ... service information (i.e., 1982 engines may incorporate design features ... If future service is required for this engine, consult GM Parts catalogs, GM Parts and ... revisions. Before installing this engine, refer to the appropriate vehicle ... climate conditions. Prime system and check oil level on dipstick. Add oil as ... necessary components to the replacement engine. Thoroughly clean all old parts to ... manifold bolt MUST go through the engine lift bracket or an equivalent thickness ... lifter noise and possible damage to the engine. Rocker cover installation: A) use RTV ...
GOODWRENCH SERVICE REPLACEMENT ENGINES Section V Page 45 August 2004 ... , Buick 1984 Pontiac P (LR8)(2.5R) Engine-Specific Content: Front Cover and Oil Pan ... INSTRUCTIONS The Goodwrench 2.5 engine has been remanufactured subsequent to ... service information (i.e., 1982 engines may incorporate design features ... If future service is required for this engine, consult GM Parts catalogs, GM Parts and ... revisions. Before installing this engine, refer to the appropriate vehicle ... climate conditions. Prime system and check oil level on dipstick. Add oil as ... necessary components to the replacement engine. Thoroughly clean all old parts to ... manifold bolt MUST go through the engine lift bracket or an equivalent thickness ... lifter noise and possible damage to the engine. Rocker cover installation: A) use RTV ...
GOODWRENCH SERVICE REPLACEMENT ENGINES Section V Page 46 August 2004 ... A, X (LR8)(2.5R) Oldsmobile, Buick Engine-Specific Content: Front Cover and Oil Pan ... INSTRUCTIONS The Goodwrench 2.5 engine has been remanufactured subsequent to ... service information (i.e., 1982 engines may incorporate design features ... If future service is required for this engine, consult GM Parts catalogs, GM Parts and ... revisions. Before installing this engine, refer to the appropriate vehicle ... climate conditions. Prime system and check oil level on dipstick. Add oil as ... necessary components to the replacement engine. Thoroughly clean all old parts to ... manifold bolt MUST go through the engine lift bracket or an equivalent thickness ... lifter noise and possible damage to the engine. Rocker cover installation: A) use RTV ...
GOODWRENCH SERVICE REPLACEMENT ENGINES Section V Page 47 August 2004 ... , Oldsmobile N (L68)(2.5U) Buick Engine-Specific Content: Front Cover and Oil Pan ... INSTRUCTIONS The Goodwrench 2.5 engine has been remanufactured subsequent to ... service information (i.e., 1982 engines may incorporate design features ... If future service is required for this engine, consult GM Parts catalogs, GM Parts and ... revisions. Before installing this engine, refer to the appropriate vehicle ... climate conditions. Prime system and check oil level on dipstick. Add oil as ... necessary components to the replacement engine. Thoroughly clean all old parts to ... manifold bolt MUST go through the engine lift bracket or an equivalent thickness ... lifter noise and possible damage to the engine. Rocker cover installation: A) use RTV ...
GOODWRENCH SERVICE REPLACEMENT ENGINES Section V Page 48 August 2004 ... , Oldsmobile N (L68)(2.5U) Buick Engine-Specific Content: Front Cover and Oil Pan ... INSTRUCTIONS The Goodwrench 2.5 engine has been remanufactured subsequent to ... service information (i.e., 1982 engines may incorporate design features ... If future service is required for this engine, consult GM Parts catalogs, GM Parts and ... revisions. Before installing this engine, refer to the appropriate vehicle ... climate conditions. Prime system and check oil level on dipstick. Add oil as ... necessary components to the replacement engine. Thoroughly clean all old parts to ... manifold bolt MUST go through the engine lift bracket or an equivalent thickness ... lifter noise and possible damage to the engine. Rocker cover installation: A) use RTV ...
GOODWRENCH SERVICE REPLACEMENT ENGINES Section V Page 49 August 2004 ... N (L68)(2.5U) w/M.T. Buick Engine-Specific Content: Front Cover and Oil Pan ... INSTRUCTIONS The Goodwrench 2.5 engine has been remanufactured subsequent to ... service information (i.e., 1982 engines may incorporate design features ... If future service is required for this engine, consult GM Parts catalogs, GM Parts and ... revisions. Before installing this engine, refer to the appropriate vehicle ... climate conditions. Prime system and check oil level on dipstick. Add oil as ... necessary components to the replacement engine. Thoroughly clean all old parts to ... manifold bolt MUST go through the engine lift bracket or an equivalent thickness ... lifter noise and possible damage to the engine. Rocker cover installation: A) use RTV ...
GOODWRENCH SERVICE REPLACEMENT ENGINES Section V Page 50 August 2004 ... N (L68)(2.5U) w/A. Trans Buick Engine-Specific Content: Front Cover and Oil Pan ... INSTRUCTIONS The Goodwrench 2.5 engine has been remanufactured subsequent to ... service information (i.e., 1982 engines may incorporate design features ... If future service is required for this engine, consult GM Parts catalogs, GM Parts and ... revisions. Before installing this engine, refer to the appropriate vehicle ... climate conditions. Prime system and check oil level on dipstick. Add oil as ... necessary components to the replacement engine. Thoroughly clean all old parts to ... manifold bolt MUST go through the engine lift bracket or an equivalent thickness ... lifter noise and possible damage to the engine. Rocker cover installation: A) use RTV ...
GOODWRENCH SERVICE REPLACEMENT ENGINES Section V Page 51 August 2004 ... , Oldsmobile N (L68)(2.5U) Buick Engine-Specific Content: Front Cover and Oil Pan ... INSTRUCTIONS The Goodwrench 2.5 engine has been remanufactured subsequent to ... service information (i.e., 1982 engines may incorporate design features ... If future service is required for this engine, consult GM Parts catalogs, GM Parts and ... revisions. Before installing this engine, refer to the appropriate vehicle ... climate conditions. Prime system and check oil level on dipstick. Add oil as ... necessary components to the replacement engine. Thoroughly clean all old parts to ... manifold bolt MUST go through the engine lift bracket or an equivalent thickness ... lifter noise and possible damage to the engine. Rocker cover installation: A) use RTV ...
GOODWRENCH SERVICE REPLACEMENT ENGINES Section V Page 52 August 2004 ... , Oldsmobile S1 (LN8)(2.5E) GMC Engine-Specific Content: Front Cover and Oil Pan Notes ... INSTRUCTIONS The Goodwrench 2.5 engine has been remanufactured subsequent to ... service information (i.e., 1982 engines may incorporate design features ... If future service is required for this engine, consult GM Parts catalogs, GM Parts and ... revisions. Before installing this engine, refer to the appropriate vehicle ... climate conditions. Prime system and check oil level on dipstick. Add oil as ... necessary components to the replacement engine. Thoroughly clean all old parts to ... manifold bolt MUST go through the engine lift bracket or an equivalent thickness ... lifter noise and possible damage to the engine. Rocker cover installation: A) use RTV ...
GOODWRENCH SERVICE REPLACEMENT ENGINES Section V Page 53 August 2004 ... , GMC M1, ST1, Z1 (LN8)(2.5E) Engine-Specific Content: Front Cover and Oil Pan ... INSTRUCTIONS The Goodwrench 2.5 engine has been remanufactured subsequent to ... service information (i.e., 1982 engines may incorporate design features ... If future service is required for this engine, consult GM Parts catalogs, GM Parts and ... revisions. Before installing this engine, refer to the appropriate vehicle ... climate conditions. Prime system and check oil level on dipstick. Add oil as ... necessary components to the replacement engine. Thoroughly clean all old parts to ... manifold bolt MUST go through the engine lift bracket or an equivalent thickness ... lifter noise and possible damage to the engine. Rocker cover installation: A) use RTV ...
GOODWRENCH SERVICE REPLACEMENT ENGINES Section V Page 54 August 2004 ... 1986 Chevrolet M1, ST1 (LN8)(2.5E) Engine-Specific Content: Front Cover and Oil Pan ... INSTRUCTIONS The Goodwrench 2.5 engine has been remanufactured subsequent to ... service information (i.e., 1982 engines may incorporate design features ... If future service is required for this engine, consult GM Parts catalogs, GM Parts and ... revisions. Before installing this engine, refer to the appropriate vehicle ... climate conditions. Prime system and check oil level on dipstick. Add oil as ... necessary components to the replacement engine. Thoroughly clean all old parts to ... manifold bolt MUST go through the engine lift bracket or an equivalent thickness ... lifter noise and possible damage to the engine. Rocker cover installation: A) use RTV ...
GOODWRENCH SERVICE REPLACEMENT ENGINES Section V Page 55 August 2004 ... 1985 Chevrolet M1, ST1 (LN8)(2.5E) Engine-Specific Content: Front Cover and Oil Pan ... INSTRUCTIONS The Goodwrench 2.5 engine has been remanufactured subsequent to ... service information (i.e., 1982 engines may incorporate design features ... If future service is required for this engine, consult GM Parts catalogs, GM Parts and ... revisions. Before installing this engine, refer to the appropriate vehicle ... climate conditions. Prime system and check oil level on dipstick. Add oil as ... necessary components to the replacement engine. Thoroughly clean all old parts to ... manifold bolt MUST go through the engine lift bracket or an equivalent thickness ... lifter noise and possible damage to the engine. Rocker cover installation: A) use RTV ...
GOODWRENCH SERVICE REPLACEMENT ENGINES Section V Page 56 August 2004 ... , Buick 1988 Pontiac P (LR8)(2.5R) Engine-Specific Content: Front Cover INSTALLATION ... INSTRUCTIONS The Goodwrench 2.5 engine has been remanufactured subsequent to ... service information (i.e., 1982 engines may incorporate design features ... If future service is required for this engine, consult GM Parts catalogs, GM Parts and ... revisions. Before installing this engine, refer to the appropriate vehicle ... climate conditions. Prime system and check oil level on dipstick. Add oil as ... necessary components to the replacement engine. Thoroughly clean all old parts to ... manifold bolt MUST go through the engine lift bracket or an equivalent thickness ... lifter noise and possible damage to the engine. Rocker cover installation: A) use RTV ...
GOODWRENCH SERVICE REPLACEMENT ENGINES Section V Page 57 August 2004 ... , Oldsmobile, N (L68)(2.5U) Buick Engine-Specific Content: Front Cover INSTALLATION ... INSTRUCTIONS The Goodwrench 2.5 engine has been remanufactured subsequent to ... service information (i.e., 1982 engines may incorporate design features ... If future service is required for this engine, consult GM Parts catalogs, GM Parts and ... revisions. Before installing this engine, refer to the appropriate vehicle ... climate conditions. Prime system and check oil level on dipstick. Add oil as ... necessary components to the replacement engine. Thoroughly clean all old parts to ... manifold bolt MUST go through the engine lift bracket or an equivalent thickness ... lifter noise and possible damage to the engine. Rocker cover installation: A) use RTV ...
GOODWRENCH SERVICE REPLACEMENT ENGINES Section V Page 58 August 2004 ... 1991 Oldsmobile, Buick N (L68)(2.5U) Engine-Specific Content: Front Cover and Oil Pan ... INSTRUCTIONS The Goodwrench 2.5 engine has been remanufactured subsequent to ... service information (i.e., 1982 engines may incorporate design features ... If future service is required for this engine, consult GM Parts catalogs, GM Parts and ... revisions. Before installing this engine, refer to the appropriate vehicle ... climate conditions. Prime system and check oil level on dipstick. Add oil as ... necessary components to the replacement engine. Thoroughly clean all old parts to ... manifold bolt MUST go through the engine lift bracket or an equivalent thickness ... lifter noise and possible damage to the engine. Rocker cover installation: A) use RTV ...
GOODWRENCH SERVICE REPLACEMENT ENGINES Section V Page 59 August 2004 ... GMC 1991-93 GMC Z1 (LLV)(L38)(2.5A) Engine-Specific Content: Front Cover and Oil Pan ... INSTRUCTIONS The Goodwrench 2.5 engine has been remanufactured subsequent to ... service information (i.e., 1982 engines may incorporate design features ... If future service is required for this engine, consult GM Parts catalogs, GM Parts and ... revisions. Before installing this engine, refer to the appropriate vehicle ... climate conditions. Prime system and check oil level on dipstick. Add oil as ... necessary components to the replacement engine. Thoroughly clean all old parts to ... manifold bolt MUST go through the engine lift bracket or an equivalent thickness ... lifter noise and possible damage to the engine. Rocker cover installation: A) use RTV ...
GOODWRENCH SERVICE REPLACEMENT ENGINES Section V Page 60 August 2004 ... , A (LR8)(2.5R) Oldsmobile, Buick Engine-Specific Content: Front Cover and Oil Pan ... INSTRUCTIONS The Goodwrench 2.5 engine has been remanufactured subsequent to ... service information (i.e., 1982 engines may incorporate design features ... If future service is required for this engine, consult GM Parts catalogs, GM Parts and ... revisions. Before installing this engine, refer to the appropriate vehicle ... climate conditions. Prime system and check oil level on dipstick. Add oil as ... necessary components to the replacement engine. Thoroughly clean all old parts to ... manifold bolt MUST go through the engine lift bracket or an equivalent thickness ... lifter noise and possible damage to the engine. Rocker cover installation: A) use RTV ...
GOODWRENCH SERVICE REPLACEMENT ENGINES Section V Page 115 August 2004 ... Chevrolet, GMC CK1(06) G1 (LS9)(350L) Engine-Specific Content: Front Cover, Oil Pan, and ... Goodwrench 5.7 Liter (350 C.I.D.) V8 engine is to be used on 1973 through 1985 ... L" and 1973 through 1985 Chevrolet- GMC light duty truck with VIN "Y" or "L". Not to ... and crankshaft before installing engine. Check engine restrictor at center of ... manifold side gaskets from replaced engine and procure one of the following units ... front cover assembly from replaced engine. Some models may require R.H. cylinder ... opposite of dipstick location. This engine is built to production point of build ... .7L 1997-98 Chevrolet Y (LS1)(5.7G) Engine-Specific Content: Front Cover, Harmonic Balancer ...
