Page 119 of Camper Products by Go Westy

www.gowesty.com call toll free 1.888.469.3789 local/international 805.528.7888 121 GoWesty offers completely rebuilt and recalibrated speedometer/odometer assemblies for $149.95 exchange ($100 core) that addresses both problems. Unlike other suppliers that sell only new speedometers or rebuilt speedometers with all zeroes reading on the odometer, GoWesty will custom build you a speedometer assembly with the odometer reading set to same or greater reading as the current reading on your existing speedometer. When you place your order for a rebuilt unit, you can discuss with the salesperson what your odometer is currently reading, how long it has not been working, and what best to set it to. We send you out a rebuilt speedometer set to the agreed upon reading. When you get the new speedo you swap it out and send back your old one to get back your $100 deposit. If your Vanagon has factory installed cruise control, donft forget to remove and keep the cruise speed sensor! Beware: If the speedometer you send back has MORE miles on it than the one we sent you, you will be getting a call from us and a visit by your local law enforcement official! Call us toll free 888-469-3789 to order your rebuilt speedo today. Cheers! Ten to fifteen years is what you could expect from the system between overhauls, until MTBE was introduced. After MTBE was introduced in California, the system was good for as little as two years. Vanagons were not the only vehicles adversely affected by the introduction of MTBE. Most gasoline vehicles experienced some sort of fuel system/vapor control system failure, and most were many times more expensive to repair than a Vanagon. The fix on a Vanagon is to drop the fuel tank, replace all the hoses and grommets, and put it back up into place. For an experienced Vanagon shop with all the proper tools and parts, it is about a two-hour job, $250 tops. For an individual without experience, itfs about a four hour job, plus the cost of our gFuel Tank Reseal Kith. Keep the faith. And donft forget, NO SMOKING! The Vanagon Leaky Fuel Tank Syndrome. When I fill my tank, why is there always a puddle under my van? Whatfs the deal? Holy crap, there is gas spilling out of my Vanagon! The problem that you are experiencing has to do with the vapor control system on Vanagon fuel tanks. The fuel tank on all 2WD Vanagons has kind of an inverted saddle shape to it. The tank is high on both sides, and has a depression down the middle. Interestingly, the depression down the middle was put there to allow the hot air duct to pass from rear to front on air cooled Vanagons. Even though there is no purpose for it now, and even though 90% of all Vanagons ever produced were water-cooled, the fuel tank design never changed. Go figurec. The filler neck is fitted on the passenger side, at the top of one of the tall sides of the fuel tank. In order for fuel to fill up evenly on both sides of the fuel tank depressed area, VW came up with a somewhat elaborate way of venting the fuel vapor. The system is comprised of a transfer tube assembly, three grommets, and about a meter or so of 5mm fuel hose. There is also a grommet around where the filler neck enters the fuel tank. The system is good until the grommets dry up, or one end of one of the fuel hoses cracks and/or comes off. Then, the next time you fill up, N-I-A-G- R-A! Check out the areas with stars in the photo to the right. Thatfs a leaker! THE GOWESTY LIBRARY

[close]