Page 47 of Volkswagen Parts 2008 by PartsPlace Inc.

parts common to rabbit jetta golf fox scirocco `77-92 daily driver section fuel injection is simple trust me [1 fuel tanks we sell a variety of excellent recycled tanks specify year model gas or diesel 2 year guarantee from $60 call for quote remanufactured fuel injection components are less expensive than new and more than recycled many recycled parts run in short supply so this has become an affordable option ask your salesman if a remanufactured fuel pump warm-up regulator idle stabilizer control unit or other component is available for your vehicle these items are sold on an exchange basis core charges apply pre-pump two pump systems in 1985 vw® changed to a two pump system there is an in-tank pre-pump transfer pump on many models it is part of the fuel sender and accessed from under the plate under the back seat fuel pre-pump cabriolet® `85-93 golf® `85-92 [7 cis injectors are pretty simple they just spray gas continuously into the intake just above the valve they are jetta® `85-92 scirocco® `85-88 fox® `87 up #sn5723 .67.95 mechanical nothing electrical and are designed to open at #sn37377 recycled .25.00 approximately 60psi there is a spring and ball check valve which [5 pressure regulator we have good used regulators available there are about 10 different ones call with your part number [2 the main fuel pump auburn hills mi 48326 have tiny passages and consequently get clogged cleaning is impossible injectors good used recycled ones are fine add rec to the part number tech tip you can check the spray pattern of injectors in the cis/cis-e fuel systems first carefully remove all 4 injectors from the cylinder head with the injector removal tool sn3509 being sure to leave the injectors connected to the hard braided lines place injectors in a small coffee can for safekeeping then remove the large rubber boot over the air-flow sensor next to the fuel distributor have a helper turn the ignition switch to the on position and finally lift the air-flow sensor plate with a pair of pliers and watch the spray pattern coming out of the injectors gas will be spraying out so be sure to have the injectors in a container to prevent accidental ignition the spray from each injector should be a fine cone-shaped mist if not you may need a new injectors this test does not work on digifant/motronic injectors they are electronic and pulse in response to a signal from the computer to test these use the procedure in the bentley manual partsplace must deliver approximately 70psi the gas runs through the pump and cools and lubricates the pump they last only about 80,000 miles so if your car does not start when the car is hot the so-called hot start there s an 80 chance it s the [2 fuel pump our pumps are bosch be careful others sell some junk brands rabbit®/jetta® all `77-84 scirocco® incl 16v `76-88 cabriolet® `85-89 dasher® #sn3433 bosch new 229.95 #sn35032 used 95.00 #sn13541 reman 119.95 vw fox® `87-88 audi 4000® 4-cyl `80-87 audi 4000® 5-cyl `80-83 4000® coupe `81-87 vw fox® `88-90 #sn9171 bosch new 219.95 #sn35034 used 98.00 #sn36656 reman 159.95 golf®/jetta®/jetta gli® `85-86 52mm #sn11959 bosch new 229.95 #sn34711 used 95.00 #sn13543 reman 139.95 golf®/jetta®/jetta gli® `85-86 gti® gli® 16v `89-92 #sn3432 60mm new 259.95 #sn34421 60mm used 95.00 #sn32677 reman 149.95 golf®/gt/gli®/jetta®/corrado® digifant 4-cyl `88-92 #sn5593 bosch new 199.95 #sn35036 used 90.00 #sn35691 reman 145.95 golf®/jetta® `93-99.5 #sn16253 new 324.95 #sn38520 good used .120.00 golf/jetta `99.5-04 #sn18639 new 299.95 #sn32296 used 50.00 vanagon® `80-92 type i® ii® 75-79 #sn3439 bosch new 249.95 #sn33181 used 100.00 #sn13545 reman 169.95 corrado® all `90.5-95/passat® vr6® `92-97 #sn18289 new call [6 fuel distributor cis injectors make bosch new used all vws® to `84 #sn3423 .79.95 15.00 all gti® `83-84 gli® `84 scirocco® `83 84 #sn3424 .59.95 25.00 golf®/jetta® `85-87 cabriolet® `85-89 fox® `87-89 gti®/gli® `85-89 quantum® `85-88 scirocco® `85-88 all #sn3425 .79.95 30.00 fax 248 373-5950 meters the fuel out to the four injectors its controlled by a pin which is lifted by the arm of the air flow the higher the arm the higher the pin the more fuel these don t wear out they just get plugged up with junk and dirt the bentley man-manuals show how to clean them but your chances of success are less than 50/50 our recycled units are 100 fine and assuming you get rid of the bad fuel and junk they should last 500,000 miles 248 373-2300 p.s don t disassemble the fuel distributor no gaskets are available changing the fuel distributor is a job you can do yourself there are multiple models of fuel distributors-when you call give year fuel injector tool and engine size we can supply you with a make quick work remanufactured unit at significant savings off of pulling out the bosch list price injectors remanufactured also available call for exact model application 2300 n opdyke cis injector puller #sn3509 $7.95 if you need a fuel distributor don t be afraid to buy an excellent recycled unit we always have a great selection of original equipment bosch fuel distributors don t be talked into spending more than you have to solutions available all models most from $85 125 fuel distributors save save inc.com digifant/motronic injectors remanufactured fuel injection components are less expensive than new and more than recycled many recycled parts run in short supply so this has become an affordable option ask your salesman if a remanufactured fuel pump warm-up regulator idle stabilizer control unit or cabriolet® `90-93 fox® `91-93 golf® `88-92 golf gti® 8v `90-92 jetta® 8 valve `88-92 #sn18711 30.00 high performance corrado® g-60® `89-92 #sn9617 99.95 golf®/jetta iii® 4 cyl `93-99.5 cabriolet® `95-02 #sn16747 38.00 other component is available for your vehicle core charge $20.00 note we have recently found a reliable remanufacturer these items are sold on an exchange basis core of fuel pumps it s a family business and they have been charges apply rebuilding electrical components for over 30 years t-46 www.partsplaceinc.com 248-373-2300

[close]