Page 63 of Volkswagen Parts 2008 by PartsPlace Inc.

parts common to rabbit jetta golf fox scirocco `77-92 daily driver section heat it up or cool it down water 10 11 14 on `81 models you must measure your water pumps pulley mounting flange see photo below for rabbit® scirocco® jetta® dasher® #1322 2 $39.95 #5013 1-1/2 35.00 #1322 1/2 12 1 13 12 2 10 water pumps bolts tend to snap off in these when you take them apart order one when you replace the pump to be safe all 4-cyl vw® and audi® `74 84 #sn11556 new $37.50 #sn30223 recycled 20.00 housing `85-99.5 #sn1326 new $37.50 #sn35680 recycled .20.00 #5013 11 water pump housing 13 gasket between housing water pump all 4-cyl for above housings and pumps exc vanagon® #sn1327 $1.80 set of bolts to install pump #sn16079 $2.39 the volkswagen® water pump lasts a long time don t over tighten the alternator belt as the added tension creates a burden on the water pump s bearings if water is dripping out the hole in the bottom of the pump it is bad replace the pump no rebuild kits are available for water pumps water pump all 4 cylinder vw `82-99.5 include golf® jetta® fox® quantum® 4 cyl audi 4000® 4 cyl vanagon® diesel not wasserboxer this pump has approximately 30mm diameter flange hub and 1 1/2 between bolt holes #sn5013 new 35.00 all vws® 4-cyl `74-80 water pump #sn1322 new 39.95 all vw® and audi® 5-cyl models #sn1321 new 59.95 vanagon® wasserboxer 1.9l thru `85 #sn1324 new 79.95 vanagon® wasserboxer 2.1l thru `92 #sn1325 new 79.95 g/j/nb tdi `99.5 05 #sn17931 new .8995 tdi `06 #sn20494 67.95 thermostat all rabbit® scirocco® jetta® dasher® quantum® golf® `74-98 4 cylinder the number 056-121-113-d87 is the standard one and most common #sn1329 80°c 176°f 8.95 #sn1330 87°c 189°f 7.50 thermostat vanagon® wasserboxer #sn1328 22.95 5 cyl audi®/vw® 80-90 also eurovan 92-95 #sn13407 18.95 g/j iii corrado® vs-6® #sn13298 22.95 tdi `96 03 #sn17960 13.95 g/j/nb 2.0 `99.5 05 passat 1.8t `01.5 05 #sn19805 .19.99 12 thermostat thermostat housing vs-6® `92-99 #sn15628 12.95 g/j iii® `93-99 4 cyl #sn18790 9.95 tdi® `95-03 #sn17932 23.95 flange on front of head g/j iii® tdi® `96-99.5 #sn15610 9.99 appr 2 dia for thermostat and water pump 2 req 4 cyl #sn1333 1.00 o-ring for g/j/c/p vr6® and vanagon® `83-92 #sn1332 1.99 g/j/nb 2.0 `99.5 05 passat 1.8t `01.5-05 #sn19803 1.99 14 rubber o-ring belt kits belts come in a hundred different sizes so please look belts don t last forever every 60,000 or soor whenever up your belts in your owners manual or read the size off you buy a used car and don t know it s maintainenance historyor when one of your belts is about to go maybe the belt order by size alternator belt 9.5 x 950 some of the others may last up to 80 90 or even 120,000 miles but you don t know you almost cannot tell unless it s about to grenade the book s say inspect the belts alternator water pump a/c how i say pick your number 60,000-70,000 but pick it and replace everything see our belt kits belts our part please note it s easy to order the wrong belt so please don t get mad and don t blame us if you order without checking your owner s manual and you get the wrong belt change all your belts at the same time with our complete belt kit all g/j `85-92 gas w/ac and p.s 8 16v #9705 $22.95 all r/j `81-84 gas w/ac #14420 14.95 all g/j iii `93-99.5 gas 4-cyl cabrio `95-02 includes serp belt and ps v-belt #14422 29.95 all g/j iii `93-99.5 vr6® gas w/ac p.s includes serp belt #15429 49.95 fox® `87-93 w/ac #15296 14.95 passat® `90-92 4 cyl w/ac #9705 22.95 rabbit® jetta® `81-84 diesel td w ac w/o ps #18031 14.95 golf®/jetta® `85-92 diesel td w/ac ps #12078 18.95 all golf®/jetta® iv`99.5-05 with 4 cyl gas engine standard engine and all 4 cylinders 1.8t enginejust one serpentine belt #18620 29.95 all golf®/jetta® iv`99.5-05 with tdi® engine #18647 29.95 sizemm us 10 10 10 10 10 10 10 10 10 10 10 10 10 10 10 13 13 13 13 13 xxxxxxxxxxxxxxxxxxxx 617 630 643 675 700 730 735 800 825 850 865 875 940 965 1075 825 950 960 1030 1150 sn09215 sn03645 sn03646 sn04258 sn03647 sn09211 sn03648 sn09213 sn03649 sn03650 sn09207 sn03651 sn03654 sn03656 sn03658 sn09209 sn03665 sn03661 sn03662 sn03664 8.95 7.95 4.50 6.95 4.95 9.95 9.95 6.95 4.95 4.95 9.95 5.00 5.00 4.50 6.95 11.95 9.95 9.95 11.95 14.95 t-62 www.partsplaceinc.com 248-373-2300

[close]