Page 22 of Volkswagen Starters - Alternators - Fuel Injection by PartsPlace Inc.

heat it up or cool it down daily driver section water 10 11 on `81 models you must measure your water pumps pulley mounting flange see photo below for rabbit® scirocco® jetta® dasher® #1322 2 93.50 35.00 12 14 #1322 1 1/2 13 12 2 10 water pumps #5013 12 thermostat thermostat all rabbit® scirocco® jetta® dasher® quantum® golf® `74-98 4 cylinder the number 056-121-113-d87 is the standard one and most common dealer us #sn1329 80°c 176°f .18.70 .8.95 #sn1330 87°c 189°f .18.70 .7.50 thermostat vanagon® wasserboxer #sn1328 .33.65 .22.95 5 cyl audi®/vw® 80-90 also eurovan 92-95 #sn13407 .18.95 g/j iii corrado® vr-6® #sn13298 .22.95 tdi `96 03 #sn17960 .1395 g/j/nb 2.0 `99.5 05 passat 1.8t `01.5 05 #sn19805 .1999 11 water pump housing bolts tend to snap off in these when you take them apart order one when you replace the pump to be safe all 4-cyl vw® and audi® `74 84 #sn11556 new 55.10 37.50 #sn30223 recycled .55.10 .20.00 housing `85-99.5 #sn1326 new 37.50 #sn35680 recycled .20.00 13 gasket between housing water pump all 4-cyl for above housings and pumps exc vanagon® #sn1327 2.05 1.40 set of bolts to install pump sn16079 1.99 the volkswagen® water pump lasts a long time don t over tighten the alternator belt as the added tension creates a burden on the water pump s bearings if water is dripping out the hole in the bottom of the pump it is bad replace the pump no rebuild kits are available for water pumps water pump all 4 cylinder vw® `82-99.5 include golf® jetta® fox® quantum® 4 cyl audi 4000® 4 cyl vanagon® diesel not wasserboxer this pump has approximately 30mm diameter flange hub and 1 1/2 between bolt holes dealer us #sn5013 new 83.15 .35.00 ® all vws 4-cyl `74-80 water pump #sn1322 new .83.15 .35.00 all vw® and audi® 5-cyl models #sn1321 new .124.10 .54.95 vanagon® wasserboxer 1.9l thru `85 #sn1324 new .176.75 .99.95 vanagon® wasserboxer 2.1l thru `92 #sn1325 new .176.75 .99.95 g/j/nb tdi `99.5 05 #sn17931 new 18815 .8995 tdi `06 #sn20494 67.95 4 pito thermostat housing vr-6® `92-99 #sn15628 .11.95 g/j iii® `93-99 4 cyl #sn18790 .9.95 tdi® `95-03 #sn17932 .23.95 flange on front of head g/j iii® tdi® `96-99.5 #sn15610 .12.50 appr 2 dia for thermostat and water pump 2 req 4 cyl #sn1333 .2.25 .1.00 o-ring for g/j/c/p vr6® and vanagon® `83-92 #sn1332 .2.25 .1.50 g/j/nb 2.0 `99.5 05 passat 1.8t `01.5-05 #sn19803 100 14 rubber o-ring e h t cp i tbelts don t last forever every 60,000 or soor whenever you buy a used car and don t know it s maintainenance historyor when one of your belts is about to go maybe some of the others may last up to 80 90 or even 120,000 miles but you don t know you almost cannot tell unless it s about to grenade the book s say inspect the belts how i say pick your number 60,00070,000 but pick it and replace everything change all your belts at the same time with our complete belt kit all g/j `85-92 gas w/ac and p.s 8 16v #9705 22.95 all r/j `81-84 gas w/ac #14420 .14.95 all g/j iii `93-99.5 gas 4-cyl cabrio `95-02 includes serp belt and ps v-belt #14422 .29.95 all g/j iii `93-99.5 vr6® gas w/ac p.s includes serp belt #15429 .59.95 fox® `87-93 w/ac #15296 .14.95 passat® `90-92 4 cyl w/ac #9705 .22.95 rabbit® jetta® `81-84 diesel td w ac w/o ps #18031 .14.95 golf®/jetta® `85-92 diesel td w/ac ps #12078 .19.95 all golf®/jetta® v`99.5-05 with 4 cyl gas engine standard engine and all 4 cylinders 1.8t enginejust one serpentine belt #18620 .24.50 all golf®/jetta® v`99.5-05 with tdi® engine #18647 .29.50 belt kits belts come in a hundred different sizes so please look up your belts in your owners manual or read the size off the belt order by size alternator belt 9.5 x 950 alternator water pump a/c belts sizemm our part dealer us please note it s easy to order the wrong belt so please don t get mad and don t blame us if you order without checking your owners manual and you get the wrong belt p-62 10 10 10 10 10 10 10 10 10 10 10 10 10 10 10 13 13 13 13 13 xxxxxxxxxxxxxxxxxxxx 617 630 643 675 700 730 735 800 825 850 865 875 940 965 1075 825 950 960 1030 1150 sn09215 sn03645 sn03646 sn04258 sn03647 sn09211 sn03648 sn09213 sn03649 sn03650 sn09207 sn03651 sn03654 sn03656 sn03658 sn09209 sn03665 sn03661 sn03662 sn03664 13.85 14.40 10.40 11.60 10.40 15.60 15.60 7.50 18.45 19.05 19.05 8.56 6.10 16.50 14.70 16.75 19.80 16.41 23.95 20.75 8.95 7.95 4.50 6.95 4.95 9.95 9.95 6.95 4.95 4.95 9.95 5.00 5.00 7.00 6.95 11.95 9.95 9.95 13.95 14.95 not just for do-it-yourselfers!

[close]